For the best BBQ parties, you need to get a hold of a finger-licking-good BBQ sauce recipe. Once you do, you can simply make some in advance to use for later; you can even gift to your friends and family.
A good BBQ sauce is used when grilling meats but can also be incorporated in many other recipes. You can give a dish a boost in taste by just adding a dash of this sweet yet tangy condiment. To do this, you need to learn how to can BBQ sauce.
How to Can BBQ Sauce
To make sure that your famous tasty BBQ sauce lasts for months, follow the given instructions below. The step-by-step guide we prepared below is made easy for even the beginners in the kitchen to follow.
- Half-pint jars with lids and rings
- Medium-sized saucepan or a canner
- Canning rack
- Jar lifter tongs
Below, we will share with you the steps to doing the water bath canning method. This technique is perfect for preserving foods with high acidities like fruits, jams, salsas, and tomato-based sauces.
Step 1: Prep the Pot
The first step includes prepping your large pot or a boiling-water canner. Washing them thoroughly under hot water using a mild detergent. Then, add water into the pot according to the size of your jars.
For pint-size jars, the pot must be two-thirds full. For quart jars, the pot must be half full. After this, set the canning rack on the pan rim, cover it with a lid, and boil the water over high heat.
Step 2: Prep the Jars
It is very important to make sure that all your utensils are sterilized before canning your BBQ sauce. While the water is boiling in the canner, wash all your jars along with their lids and rings. Do this thoroughly using hot water and detergent. You can also use a dishwasher with heat or sanitizing settings on.
Next, when the water has started boiling, place the sterilized jars on the rack and lower them into the water. Boil them for 10 minutes, increasing one minute for every 1,000 feet above sea level.
Reduce the flame after 10 minutes of boiling, keeping the jars in the simmering water until they are needed. Place the lids and bands together in a 2- to 3-quart pot and fill it with water. Set the pot over a high flame but make sure not to boil the water. Remove it from the flame after the water has started simmering. Then, cover it with a lid.
Step 3: Put the Sauce In
After removing the jars, place a sanitized wide funnel on top and scoop the sauce into them. Make sure to leave headspace of almost half-inch to a quarter inch from the rim.
In case of air bubbles, run a rubber spatula on the inside of the jar. Then, clean the rims using a clean, hot towel, removing any excess BBQ sauce. Using a clean pair of tongs, remove the lids and bands from the hot water and screw them onto the jar.
Step 4: The Water Bath
Place the jars back on the rack and in the water. Make sure that they are covered at least one inch by the water. Next, cover your pot or canner with the lid again and heat it for 15 minutes on medium to high heat. Following this, turn off the heat and let the jar sit in the water for another five minutes.
Step 5: Cool Them Down
Using jar lifting tongs, remove your jars from the hot water and place them on a clean towel on your counter. Without tightening the bands, leave the jars undisturbed at room temperature for the next 12 to 24 hours. For the best results, place the jars more than an inch apart from each other for maximum cooling.
Step 6: Check the Seals
The next step involves checking the jars for their seal. When pressed on their center, the lids should not move up and down if they are sealed properly. In case the lid pops up, you should refrigerate them, and use those jars first.
After checking their seals, remove the bands from the jar and clean the top of the lid carefully with a clean paper towel. It is optional to replace the bands but make sure not to screw on too tightly, or the seal may break.
Step 7: Labeling
Label the BBQ sauce jars, and place them in a cool area away from sunlight.
How Long Can You Store BBQ Sauce?
Now that you have made your delicious BBQ sauce in bulk and canned them perfectly, you can store them for over two years. This allows you to use them one jar at a time for all sorts of recipes like chicken sandwiches, wraps, burritos, and even pizza. Once you have opened up a sealed jar, place the leftovers in the fridge and use them within two to three weeks.
Why Is It Important to Can BBQ Sauce?
Canning BBQ sauce increases its shelf-life from a few weeks to almost two years. Since high heat is used in this method, most bacteria and other germs are killed during the processing. Along with this, sterilization of the jars, lids, and pot further helps in killing the bacteria responsible for spoiling the sauce.
While heating, the air is also driven out of the jar, and the vacuum seal prevents the entry of any air. Such that, bacteria cannot grow in the absence of oxygen, and the sauce remains sterilized. Thus, this process helps to preserve the original flavor and color of your BBQ sauce for a long time.
For a better barbeque try a BBQ Box – Hand selected and delivered to your door monthly!
If you are planning to make your BBQ sauce in bulk for later use or to gift it to your friends and family, make sure to read this article thoroughly about how to can bbq sauce and follow the canning method carefully.
The canning method will increase the life of your treasured BBQ sauce, allowing you to crack open the seal on one of the jars any time and using it for all sorts of dishes. With a premade homemade sauce, an impromptu BBQ party will be a piece of cake for you every time.
Sign-up for updates and eBook- A Beginners Comprehensive Guide to Charcoal Grilling
Amazon Affiliate Policy